Impact of source-separation of urine on treatment capacity, process design, and capital expenditure of a decentralised wastewater treatment plant.

In this study, the impact of urine diversion on the treatment capacity, treatment process, and capital costs of a decentralised wastewater treatment plant (WWTP) was simulated using BioWin. The data for simulation including for economic analysis were obtained from a real decentralised WWTP at Sydney. Simulation was conducted for two alternative process design scenarios of a WWTP: membrane bioreactor (MBR) without denitrification and anaerobic MBR in place of aerobic MBR and compared to existing process design. The simulation shows that with about 75% urine diversion (through source separation), the treatment capacity of the existing WWTP can be doubled although above 40% urine diversion, the impact appears less rapid. When the urine diversion exceeds 75%, it was found that the anoxic tank for biological denitrification becomes redundant and the current wastewater treatment process could be replaced with a simpler and much less aeration intensive membrane bioreactor (MBR) producing similar effluent quality with a 24% reduction in capital expenditure (footprint) cost. Anaerobic MBR can be a potential alternative to aerobic MBR although pre-treatment becomes essential before reverse osmosis treatment for water reuse applications. Sensitivity analysis has revealed that by operating the bioreactor at higher mixed liquor suspended solids concentrations (9 g/L instead of 5 g/L) could help increase the WWTP treatment capacity by about 3.5 times at 75% urine diversion. Hence, urine diversion (until nitrogen-limiting conditions occur above 75% urine diversion) can increase the treatment capacity of an existing WWTP and reduce the capital expenses due to reduced plant footprint.

On-site domestic wastewater treatment system using shredded waste plastic bottles as biofilter media: Pilot-scale study on effluent standards in Bhutan.

In this study, a 1000 L/d capacity one-off on-site wastewater treatment system was operated for over a year as a pilot alternative to the conventional on-site treatment as currently used in urban Bhutan. An up-flow anaerobic sludge blanket (UASB) was used for blackwater treatment (to replace "septic tank followed by an anaerobic biofilter (ABF) (to replace soak pits) for the treatment of a mixture of greywater and UASB effluent. Shredded waste plastic bottles were used as the novel biofilter media in the ABF. During a yearlong operation, the pilot system produced a final treated effluent from ABF with average BOD5 28 mg/L, COD 38 mg/L, TSS 85 mg/L and 5 log units of Escherichia coli. These effluents met three out of four of the national effluent discharge limits of Bhutan, but unsuccessful to meet the Escherichia coli standard over a yearlong operation. Further, process optimisation may enable more significant Escherichia coli removal. An economic analysis indicates that the total unit cost (capital and operating expenditures) of this alternative wastewater treatment system for more than 50 users range between USD 0.27-0.37/person/month comparable to USD 0.29-0.42/person/month for the current predominant on-site system, i.e., "septic tanks". This pilot study, therefore, indicates that this wastewater treatment system using shredded waste plastic biofilter media has high potential to replace the current conventional treatment, i.e., "septic tanks", which are often overloaded with greywater and discharging effluents which does not meet the national standards.

Urine Treatment on the International Space Station: Current Practice and Novel Approaches.

A reliable, robust, and resilient water recovery system is of paramount importance on board the International Space Station (ISS). Such a system must be able to treat all sources of water, thereby reducing resupply costs and allowing for longer-term space missions. As such, technologies able to dewater urine in microgravity have been investigated by different space agencies. However, despite over 50 years of research and advancements on water extraction from human urine, the Urine Processing Assembly (UPA) and the Water Processor Assembly (WPA) now operating on the ISS still achieve suboptimal water recovery rates and require periodic consumables resupply. Additionally, urine brine from the treatment is collected for disposal and not yet reused. These factors, combined with the need for a life support system capable of tolerating even dormant periods of up to one year, make the research in this field ever more critical. As such, in the last decade, extensive research was conducted on the adaptation of existing or emerging technologies for the ISS context. In virtue of having a strong chemical resistance, small footprint, tuneable selectivity and versatility, novel membrane-based processes have been in focus for treating human urine. Their hybridisation with thermal and biological processes as well as the combination with new nanomaterials have been particularly investigated. This article critically reviews the UPA and WPA processes currently in operation on the ISS, summarising the research directions and needs, highlighted by major space agencies, necessary for allowing life support for missions outside the Low Earth Orbit (LEO). Additionally, it reviews the technologies recently proposed to improve the performance of the system as well as new concepts to allow for the valorisation of the nutrients in urine or the brine after urine dewatering.